Power windows and sunroof problems (solution)

[Matt Zajac <MTZajac@beloit.com>]

Per VW Technical Bulletin:

Technical Bulletin
C
W 1997 Volkswagen of America, Inc.
1
Subject:
Model(s):
Group:
Number:
Date:
Convenience Close Feature, Sunroof Will Not Close
1995 
60
97*03
Sept. 9, 1997 Passat w/Power Windows and Sunroof
Supersedes T.B. Group 60 Number 96*01 dated Aug. 14, 1996
Reference to Golf, GTI, Jetta removed.
Condition
When using Convenience Close Feature (key in
outside door lock to close windows and
sunroof), sunroof does not close after windows
close.
Service
When this condition exists:
* Switch ignition ON.
* Lower ALL windows to full open position.
* Open sunroof to full open position.
* Disconnect each power window regulator
connectors at respective A and B Pillars .
* Switch ignition OFF.
* Allow vehicle to sit with ignition switched OFF
for 5 min. before proceeding with the
following steps:
* Switch ignition ON.
* Connect left front door window regulator
connector at A*Pillar.
* Raise left front window to full closed position.
* Connect right front door window regulator
connector at A*Pillar.
* Raise right front door window to full closed
position.
* Connect left rear door window regulator
connector at B*Pillar.
(Cont. on Page 2)

Technical Bulletin
C
W 1997 Volkswagen of America, Inc.
2
* Raise left rear door window to full closed
position.
* Connect right rear door window regulator
connector at B*Pillar.
* Raise right rear door window to full closed
position.
Note:
Each regulator must be connected then
raised to the full closed position before
proceeding to the next regulator.
* All windows should be in the full closed
position.
* Using the key in the driver*s door operate
convenience open feature and lower all
windows to full open position.
* Operate convenience close feature (close all
windows to full closed position), continue
holding key and sunroof should now close.
Windows and sunroof are now synchronized.
When procedure applies to vehicles within
warranty use the following:
Part Identifier: 6039
Labor Operation: 6039610 30 T.U.


Hope it helps.... :-))

Matt 
'98 red jetta glx, modded

Matt Zajac
Technical Analyst
Beliot Corporation
E-Mail: MTZajac@beloit.com
Tel: (847) 229-5843
Fax: (847) 229-5880