[Date Prev][Date Next][Thread Prev][Thread Next][Date Index][Thread Index]
Re: Power windows and sunroof problems (solution)
OK, Thanks. Where are these connectors and pillars, exactly?
Regards,
John Kiekhaefer
Matt Zajac wrote:
> Per VW Technical Bulletin:
>
> Technical Bulletin
> C
> W 1997 Volkswagen of America, Inc.
> 1
> Subject:
> Model(s):
> Group:
> Number:
> Date:
> Convenience Close Feature, Sunroof Will Not Close
> 1995
> 60
> 97*03
> Sept. 9, 1997 Passat w/Power Windows and Sunroof
> Supersedes T.B. Group 60 Number 96*01 dated Aug. 14, 1996
> Reference to Golf, GTI, Jetta removed.
> Condition
> When using Convenience Close Feature (key in
> outside door lock to close windows and
> sunroof), sunroof does not close after windows
> close.
> Service
> When this condition exists:
> * Switch ignition ON.
> * Lower ALL windows to full open position.
> * Open sunroof to full open position.
> * Disconnect each power window regulator
> connectors at respective A and B Pillars .
> * Switch ignition OFF.
> * Allow vehicle to sit with ignition switched OFF
> for 5 min. before proceeding with the
> following steps:
> * Switch ignition ON.
> * Connect left front door window regulator
> connector at A*Pillar.
> * Raise left front window to full closed position.
> * Connect right front door window regulator
> connector at A*Pillar.
> * Raise right front door window to full closed
> position.
> * Connect left rear door window regulator
> connector at B*Pillar.
> (Cont. on Page 2)
>
> Technical Bulletin
> C
> W 1997 Volkswagen of America, Inc.
> 2
> * Raise left rear door window to full closed
> position.
> * Connect right rear door window regulator
> connector at B*Pillar.
> * Raise right rear door window to full closed
> position.
> Note:
> Each regulator must be connected then
> raised to the full closed position before
> proceeding to the next regulator.
> * All windows should be in the full closed
> position.
> * Using the key in the driver*s door operate
> convenience open feature and lower all
> windows to full open position.
> * Operate convenience close feature (close all
> windows to full closed position), continue
> holding key and sunroof should now close.
> Windows and sunroof are now synchronized.
> When procedure applies to vehicles within
> warranty use the following:
> Part Identifier: 6039
> Labor Operation: 6039610 30 T.U.
>
> Hope it helps.... :-))
>
> Matt
> '98 red jetta glx, modded
>
> Matt Zajac
> Technical Analyst
> Beliot Corporation
> E-Mail: MTZajac@beloit.com
> Tel: (847) 229-5843
> Fax: (847) 229-5880
> !
> !
> !
> !
>
> !
> !
> !
> !
>
>